Use of Broken Photovoltaic Glass

Can a glass breakage damage a PV module?

Glass breakage, without any extreme weather event or other obvious cause, is being reported on a small yet significant number of PV projects. This issue comes with the potential to damage PV module performance in the long term, or even cause safety hazards – and we will need to act fast to find both the cause and a practical solution.

Does glass defect reparation damage PV cells?

Furthermore, the research analyzed the economic and energetic impact of glass defect reparation in comparison with regular substitution. We found that glass-glass PV modules which endured glass defects did not show performance loss, nor internal damage to the PV cells.

How do glass defects affect a PV system?

Glass defects impact the economic performance of a PV system in multiple ways. The most obvious effect is the potential (in)direct performance loss of PV modules, which results in reduced economic revenues. Secondly, PV modules that suffer from glass defects may no longer meet safety requirements, therefore these modules are replaced.

Are glass-glass PV modules a problem?

Unfortunately, glass-glass PV modules are, similar to regular PV modules, subject to early life failures. A failure of growing concern are defects in the glass layer (s) of PV modules. The scale of decommissioned PV modules with glass defects will increase with the development of solar PV energy [ 7 ].

Can PV modules survive a glass defect?

However, glass defects do not directly imply that PV modules endure internal damage nor that PV modules cannot continue to operate with minimal microcracks. Thus far, glass defects have been regarded as a failure beyond repair and no noticeable attempt has been made to develop reparation methods.

How are glass defect PV modules treated?

After the initial tests, the glass defect PV modules were divided into two subgroups: repaired specimen and non-repaired specimen. The repaired specimen were treated with the experimental repair technique, whereas the non-repaired specimen were left untreated as reference.